1.5L – Low Oil Pressure Warning With DTC P0524 – 2020-2021 Ford Escape & 2021 Bronco Sport

2021 Ford Bronco Sport

NHTSA ID Number: 10191097 Manufacturer Communication Number: SSM 49744   Summary Some 2020-2021 Escape/2021 Bronco Sport vehicles equipped with a 1.5L engine may exhibit a low oil pressure warning with diagnostic trouble code (DTC) P0524. The Workshop Manual (WSM) Sections 303-14, 303-00, and 413-01 have been updated with new information to aid in diagnosis of the low … Read more

Front Wind Noise Whistle – 2021 Ford Bronco Sport

2021 Ford Bronco Sport

NHTSA ID Number: 10187923 Manufacturer Communication Number: SSM 49630   Summary Some 2021 Bronco Sport vehicles built on 01-Oct-2020 and through 31-Dec-2020 could experience a whistle noise coming from the front of the vehicle at highway speeds. To correct this condition, adjust the hood rearward. Refer to Workshop Manual (WSM) Section 501-03>General procedures>Hood alignment (NOTE: hood to … Read more

Customer Satisfaction Program 21B19 – AWD Module Replacement – 2020-2021 Ford Bronco Sport, Escape, & Lincoln Corsair

2021 Ford Bronco Sport

NHTSA ID Number: 10191184 Manufacturer Communication Number: 21B19   Summary In all of the affected vehicles, the AWD module was assembled with an incorrect transistor that controls the transition between AWD and 2WD. When this transistor fails the vehicle will remain in either AWD or 2WD and not transition between the drive states. This can cause the … Read more

AWD – Chatter/Shudder During Low Speed Turning Events – 2019-2021 Ford Edge/Lincoln Nautilus, 2020-2021 Escape/Corsair, 2021 Bronco Sport

2021 Ford Edge

NHTSA ID Number: 10187981 Manufacturer Communication Number: SSM 49571   Summary Some 2019-2021 Edge/Nautilus, 2020-2021 Escape/Corsair, 2021 Bronco Sport vehicles equipped with all wheel drive (AWD) may exhibit chatter/shudder during low speed turning events due to fluid contamination. Drain and refill the rear drive unit (RDU), refer to Workshop Manual Section (WSM) 205-02. Drive for 8 km … Read more

Headlamp Dark Spots Pattern – 2021 Ford Bronco Sport

2021 Ford Bronco Sport

NHTSA ID Number: 10189555 Manufacturer Communication Number: SSM 49645   Summary All 2021 Bronco Sport vehicles have headlamp low beam pattern with a dark spot dip near the horizon in the left portion of the beam pattern. These dark spots are most noticeable when the high beam is active. Although this dark spot is present by design, … Read more