Ford Lincoln & Mercury Recalls, Technical Service Bulletins TSB's, Diagnostic & Repair Tips
BUCK/JERK STEADY THROTTLE OR SLIGHT TIP IN – 6.0L – BUILT ON OR BEFORE 3/15/2006 FORD
: 2005-2006 F-Super Duty 2005-2006 F-Super Duty vehicles built on or before 3/15/2006 equipped with a 6.0L engine may exhibit a buck/jerk condition in Low (L), first (1st), or second (2nd) in manual transmission vehicles, or in manual … Read more
8.8 LIMITED SLIP AXLE MOAN/GROAN NOISE DURING LOW SPEED TURNING MANEUVERS FORD: 2005-2007 Mustang 2005-2007 Mustang GT vehicles equipped with the 8.8 inch limited slip axle may exhibit a moan/groan noise when making tight low speed turns. This may be more noticeable when the axle is at full operating temperature. The noise may … Read more
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY – CLIMATE CONTROL DEFAULTS TO DEFROST MODE FORD: 1999-2006 F-Super Duty 2000-2005 Excursion 1999-2006 F-650, F-750 1999-2006 F-Super Duty and 2000-2005 Excursion vehicles built before 6/27/2005 and 1999-2006 F650/750 vehicles, all vehicles equipped with the 7.3L or 6.0L diesel engine, may exhibit a vacuum pump that is … Read more
MOAN/VIBRATION DURING A/C OPERATION FORD: 2001-2005 Explorer Sport Trac 2001-2005 Explorer Sport Trac vehicles may exhibit a moan/vibration coming from the engine compartment while the A/C is on and the engine is at low RPM. The noise will only occur when the A/C compressor is running. ACTION: Replace the manifold and … Read more
AXLE WHINE FORD: 2005-2010 Mustang 2005-2010 Mustang vehicles may exhibit excessive axle whine noise. SERVICE PROCEDURE This condition may be corrected by installing tuned dampers on the rear axle assembly, if not already installed. Figure 1 Figure 2 NOTE: NO DRILLING IS REQUIRED IF DAMPER MOUNTING HOLES ARE PRESENT. VEHICLES BUILT … Read more