16S46 – Turbocharger Oil Supply Tube Inspection – 2016-2017 Ford & Lincoln

“This site contains affiliate links for which OEMDTC may be compensated”

NHTSA Campaign Number: 16V925
Manufacturer Ford Motor Company
Components ENGINE AND ENGINE COOLING
Potential Number of Units Affected 1,163

 

Oil Leak from Turbocharger

An oil leak, in the presence of an ignition source, increases the risk of a fire.

 

Summary

Ford Motor Company (Ford) is recalling certain model year 2016 Ford Taurus, 2016-2017 Ford Flex, Lincoln MKT, 2017 Ford Explorer and Ford Explorer Police Interceptor Utility vehicles equipped with 3.5L GTDI engines.

Improperly brazed turbocharger oil supply tubes may leak oil on engine components.

 

Remedy

Ford will notify owners, and dealers will inspect, and if necessary, replace the turbocharger oil supply tubes, free of charge.

The recall is expected to begin on January 23, 2017.

Owners may contact Ford customer service at 1-866-436-7332.

Ford’s number for this recall is 16S46.

 

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

 

Check if your Vehicle has a Recall

 

December 20, 2016

TO: All U.S. Ford and Lincoln Dealers

SUBJECT: NEW VEHICLE DEMONSTRATION / DELIVERY HOLD – Safety Recall 16S46
Certain 2016 Model Year Taurus, 2017 Model Year Explorer and Police Interceptor
Utility, and 2016-2017 Model Year Flex and MKT vehicles equipped with a 3.5L
EcoBoost Engine
Turbocharger Oil Supply Tube Inspection

 

AFFECTED VEHICLES

Vehicle Model Year Assembly Plant Build Dates
Taurus 2016 Chicago October 18, 2016 through November 2, 2016
Explorer 2017 October 15, 2016 through November 12, 2016
Police Interceptor Utility November 2, 2016 through November 2, 2016
Flex 2016-2017 Oakville October 18, 2016 through November 10, 2016
MKT October 18, 2016 through November 10, 2016

 

Affected vehicles are identified in OASIS and FSA VIN Lists.

 

REASON FOR THIS SAFETY RECALL

In some of the affected vehicles, improperly brazed turbocharger oil supply tubes may leak engine oil on the turbocharger and surrounding components.  An oil leak in the presence of an ignition source may increase the risk of fire.

 

SERVICE ACTION

Before demonstrating or delivering any new in-stock vehicles involved in this recall, dealers are to inspect the turbocharger oil supply tubes for leaks and replace if a leak is present.  This service must be performed on all affected vehicles at no charge to the vehicle owner.

 

OWNER NOTIFICATION MAILING SCHEDULE

Owner letters are expected to be mailed the week of January 23, 2017.  Dealers should repair any affected vehicles that arrive at their dealerships, whether or not the customer has received a letter.

 

PLEASE NOTE:

Federal law requires dealers to complete this recall service before a new vehicle is delivered to the buyer or lessee.  Violation of this requirement by a dealer could result in a civil penalty of up to $21,000 per vehicle.  Correct all vehicles in your new vehicle inventory before delivery.

 

ATTACHMENTS

Attachment I: Administrative Information
Attachment II: Labor Allowances and Parts Ordering Information
Attachment III: Technical Information
Owner Notification Letter

 

QUESTIONS & ASSISTANCE

For questions and assistance, contact the Special Service Support Center (SSSC) via the SSSC Web

Contact Site.  The SSSC Web Contact Site can be accessed through the Professional Technician Society (PTS) website using the SSSC link listed at the bottom of the OASIS VIN report screen or listed under the SSSC tab.

Sincerely,

 

Michael A. Berardi

 

ATTACHMENT I

NEW VEHICLE DEMONSTRATION / DELIVERY HOLD – Safety Recall 16S46
Certain 2016 Model Year Taurus, 2017 Model Year Explorer and Police Interceptor Utility, and 2016-2017 Model Year Flex and MKT vehicles equipped with a 3.5L EcoBoost Engine
Turbocharger Oil Supply Tube Inspection

 

OASIS ACTIVATION

OASIS will be activated on December 20, 2016.

 

FSA VIN LISTS ACTIVATION

FSA VIN Lists will be available through https://web.fsavinlists.dealerconnection.com on December 20, 2016.  Owner names and addresses will be available by February 3, 2017.

NOTE:  Your FSA VIN Lists may contain owner names and addresses obtained from motor vehicle registration records.  The use of such motor vehicle registration data for any purpose other than in connection with this recall is a violation of law in several states, provinces, and countries.

Accordingly, you must limit the use of this listing to the follow-up necessary to complete this recall.

 

SOLD VEHICLES

  • Owners of affected vehicles will be directed to dealers for repairs.
  • Immediately contact any of your affected customers whose vehicles are not on your VIN list but are identified in OASIS. Give the customer a copy of the Owner Notification Letter (when available) and schedule a service date.
  • Correct other affected vehicles identified in OASIS which are brought to your dealership.
  • Dealers are to prioritize repairs of customer vehicles over repairs of new and used vehicle inventory.

 

STOCK VEHICLES

  • Correct all affected units in your new vehicle inventory before delivery.
  • Use OASIS to identify any affected vehicles in your used vehicle inventory.

 

DEALER-OPERATED RENTAL VEHICLES

A new law prohibits a Rental Company from selling, renting or leasing vehicles subject to a safety or compliance recall. This could impact dealer-operated rental fleets of 35 vehicles or more, including FRAC, LRAC, and DDR vehicles.  Please see EFC04833 for details and consult your legal counsel for legal advice.

 

TITLE BRANDED / SALVAGED VEHICLES

Affected title branded and salvaged vehicles are eligible for this recall.

 

ADDITIONAL REPAIR (LABOR TIME AND/OR PARTS)

Additional repairs identified as necessary to complete the FSA should be managed as follows:

  • For vehicles within new vehicle bumper-to-bumper warranty coverage, follow existing warranty and policy guidelines for related damage claims. No SSSC approval is required for these vehicles:
    • Ford vehicles – 3 years or 36,000 miles o Lincoln vehicles – 4 years or 50,000 miles
  • For vehicles outside new vehicle bumper-to-bumper warranty coverage, submit an Approval Request to the SSSC Web Contact Site prior to completing the repair.

 

OWNER REFUNDS   

Refunds are not approved for this program.

 

RENTAL VEHICLES  

The use of rental vehicles is not approved for this program.

 

LINCOLN PICKUP AND DELIVERY

Owners of 2017 model year and newer Lincoln vehicles have the option of requesting pickup and delivery service with a Lincoln loaner, from their dealership.  For details, reference EFC04786 National Launch of Lincoln Pickup and Delivery New Owner Privileges.

 

LINCOLN CLIENT SPECIAL HANDLING

To ensure the best possible experience for Lincoln owners, Lincoln Dealers are encouraged to utilize the Lincoln Loyalty Program to provide clients with surprise and delight offerings, such as:

  • Fuel fill
  • Gift Card for the client’s favorite restaurant

The Lincoln Loyalty Program is exclusive to Lincoln Dealers. Owners will not be notified of this service in owner mailings. Reference EFC04453, Lincoln Loyalty Program Announcement for additional details

 

CLAIMS PREPARATION AND SUBMISSION

  • Enter claims using Direct Warranty Entry (DWE) or One Warranty Solution (OWS).
    • DWE: refer to ACESII manual for claims preparation and submission information.
    • OWS: when entering claims in DMS software, select claim type 31: Field Service Action. The FSA number (16S46) is the sub code.
  • Additional labor and/or parts must be claimed as related damage on a separate repair line from the FSA.
  • For Lincoln Client Special Handling, reference EFC04453, Lincoln Loyalty Program Announcement for Requirements and Claiming Instructions. Claims for Lincoln Loyalty should be submitted as a separate line on the same Repair Order.
  • Provision for Locally Obtained Supplies: An allowance is provided for locally obtaining DyeLite Gasoline Engine Oil Dye.
    • Program Code: 16S46             – Misc. Expense: OTHER
    • Expense: Claim actual cost up to $10

 

ATTACHMENT II

NEW VEHICLE DEMONSTRATION / DELIVERY HOLD – Safety Recall 16S46
Certain 2016 Model Year Taurus, 2017 Model Year Explorer and Police Interceptor Utility, and 2016-2017 Model Year Flex and MKT vehicles equipped with a 3.5L EcoBoost Engine
Turbocharger Oil Supply Tube Inspection

 

LABOR ALLOWANCES

Description Labor Operation Labor Time
Inspect Turbocharger Oil Supply Tubes for Leaks – PASS/NO LEAKS (all vehicles) 16S46A 0.6
Replace RH Turbocharger Oil Supply Tube (includes inspect) Explorer and Police Interceptor Utility 16S46B 1.9
Taurus 2.0
Flex and MKT 2.3
Replace LH Turbocharger Oil Supply Tube (includes inspect) Explorer and Police Interceptor Utility 16S46C 1.2
Taurus
Flex and MKT
Replace BOTH Turbocharger Oil Supply Tubes (includes inspect) Explorer and Police Interceptor Utility 16S46D 2.3
Taurus 2.4
Flex and MKT 2.8

 

PARTS REQUIREMENTS / ORDERING INFORMATION

Part Number Description Order Quantity Claim Quantity
-9G440- refer to catalog RH Turbocharger Oil Supply Tube 1 (as required) 1 (as required)
-9T516- refer to catalog LH Turbocharger Oil Supply Tube 1 (as required) 1 (as required)
XO-5W30-QSP 16S46 - Turbocharger Oil Supply Tube Inspection - 2016-2017 Ford & Lincoln | small light 5W-30 Motorcraft Premium Synthetic Blend Motor Oil (12 quarts per package, up to 1 quart may be required) 1 1
Obtain Locally Dye-Lite Gasoline Engine Oil Dye 1 Fluid Oz. Bottle MISC OTHER

 

The DOR/COR number for this recall is 51068.

Order your parts through normal order processing channels.  To guarantee the shortest delivery time, an emergency order for parts must be placed.

NOTE:  Less than 5% of the affected vehicle population is expected to require turbocharger oil supply tube replacement.

 

DEALER PRICE

For latest prices, refer to DOES II.

 

PARTS RETENTION AND RETURN

Follow the provisions of the Warranty and Policy Manual, Section 1 – WARRANTY PARTS RETENTION AND RETURN POLICIES.

 

EXCESS STOCK RETURN

Excess stock returned for credit must have been purchased from Ford Customer Service Division in accordance with Policy Procedure Bulletin 4000.

 

ATTACHMENT III

Certain 2016 Model Year Taurus, 2017 Model Year Explorer and
Police Interceptor Utility, and 2016-2017 Model Year Flex and MKT
vehicles equipped with a 3.5L EcoBoost EngineTurbocharger Oil
Supply Tube Inspection

 

OVERVIEW

In some of the affected vehicles, improperly brazed turbocharger oil supply tubes may leak engine oil on the turbocharger and surrounding components. An oil leak in the presence of an ignition source may increase the risk of fire. Dealers are to inspect the turbocharger oil supply tubes for leaks and replace if a leak is present.

 

SERVICE PROCEDURE

  1. With the vehicle in NEUTRAL, position it on a hoist. Please follow the procedures in Workshop Manual (WSM) Section 100-02.

NOTE: Use the 12 Volt Master UV Diagnostic Inspection Kit 164-R0756 or equivalent (Leak Detector) to carry out the following procedure for oil leak diagnosis.

  1. Add 29.6 ml (1 oz) of Dye-Lite Gasoline Engine Oil Leak Detection Dye to a minimum of 0.47L (1/2 qt) and a maximum of 0.95L (1 qt) engine oil and fill through the engine oil fill. Thoroughly premix the gasoline engine oil leak detection dye or it will not have enough time to reach the crankcase, oil galleries and seal surfaces during this particular 15 minute test. The additive must be mixed well with oil and added through the oil fill. Check the level on the oil level indicator to determine what amount of oil to premix. If it is in the middle of the crosshatch area or below the full mark, use 0.95L (1 qt). If it is at the full mark, use 0.47L (1/2 qt).
  2. Run the engine for 15 minutes. Stop the engine and inspect the RH and LH turbocharger oil supply tubes for leaks using the 12 Volt Master UV Diagnostic Inspection Kit 164-R0756 or equivalent (Leak Detector). A clear bright yellow or orange area will identify the leak. See Figure 1.

NOTE: The LH turbocharger oil supply tube can be inspected from above, and the RH turbocharger oil supply tube must be inspected from below with the vehicle positioned on a hoist.

  • If a leak is found at either turbocharger oil supply tube, replace the tube. Please follow the procedures in WSM Section 303-04.
  • If a leak is not found, verify the oil level is within the upper and lower oil indicator marks.
    Remove oil if it registers above the full mark. No additional service is required.

TURBOCHARGER OIL SUPPLY TUBEFIGURE 1

 

 

January 2017

 

* * * IMPORTANT SAFETY RECALL * * *
(PROGRAMA DE SEGURIDAD IMPORTANTE)

 

Safety Recall Notice 16S46 / NHTSA Recall 16V925
Aviso de Revisión de Seguridad 16S46

 

Mr. John Sample
123 Main Street
Anywhere, USA 12345

 

Your Vehicle Identification Number (VIN):  12345678901234567

This notice is sent to you in accordance with the National Traffic and Motor Vehicle Safety Act.

Ford Motor Company has decided that a defect which relates to motor vehicle safety exists in your vehicle, with the VIN shown above.

We apologize for this situation and want to assure you that, with your assistance, we will correct this condition.  Our commitment, together with your dealer, is to provide you with the highest level of service and support.

What is the issue? It is possible that your vehicle was built with improperly brazed turbocharger oil supply tubes that may leak engine oil on the turbocharger and surrounding components.  An oil leak in the presence of an ignition source may increase the risk of fire.
What will Ford and your dealer do? Ford Motor Company has authorized your dealer to inspect the turbocharger oil supply tubes for leaks and replace if a leak is present free of charge (parts and labor).
How long will it take? The time needed for this repair is less than one-half day.  However, due to service scheduling requirements, your dealer may need your vehicle for a longer period of time.  In addition, your vehicle will require an inspection to determine if parts need to be ordered.
What should you do? Please call your dealer without delay and request a service date for Recall 16S46. Provide the dealer with your VIN, which is printed near your name at the beginning of this letter.

If you do not already have a servicing dealer, you can access www.Fordowner.com for dealer addresses, maps, and driving instructions.

Ford Motor Company wants you to have this safety recall completed on your vehicle.  The vehicle owner is responsible for making arrangements to have the work completed.  Ford Motor Company can deny coverage for any vehicle damage that may result from the failure to have this recall performed on a timely basis.  Therefore, please have this recall performed as soon as possible.

Please note:  Federal law requires that any vehicle lessor receiving this recall notice must forward a copy of this notice to the lessee within ten days.

Your vehicle may be equipped with a diagnostic feature called the Vehicle Health Report which can inform you about all available recalls, as well as other key vehicle health information. Please see https://owner.ford.com/vehiclehealth for more information.

What if you no longer own this vehicle? If you no longer own this vehicle, and have an address for the current owner, please forward this letter to the new owner.

You received this notice because government regulations require that notification be sent to the last known owner of record.  Our records are based primarily on state registration and title data, which indicate that you are the current owner.

Can we assist you further? If you have difficulties getting your vehicle repaired promptly and without charge, please contact your dealership’s Service Manager for assistance.

RETAIL OWNERS:  If you have questions or concerns, please contact our Ford Customer Relationship Center at 1-866-436-7332 and one of our representatives will be happy to assist you.  If you wish to contact us through the Internet, our address is:  www.Fordowner.com.

For the hearing impaired call 1-800-232-5952 (TDD).  Representatives are available Monday through Friday:  8:00AM – 8:00PM(Eastern Time).

FLEET OWNERS:  If you have questions or concerns, please contact our

Fleet Customer Information Center at 1-800-34-FLEET, choose Option #3, and one of our representatives will be happy to assist you.  If you wish to contact us through the Internet, our address is:  www.fleet.ford.com.

Representatives are available Monday through Friday:  8:00AM – 8:00PM(Eastern Time).

If you are still having difficulty getting your vehicle repaired in a reasonable time or without charge, you may write the Administrator, National Highway Traffic Safety Administration, 1200 New Jersey Ave. S.E., Washington, D.C.

20590 or call the toll free Vehicle Safety Hotline at 1-888-327-4236 (TTY: 1-800-424-9153) or go to www.safercar.gov.  Reference NHTSA Safety Recall 16V925.

Para asistencia en Español Visite nuestro sitio web para ver este anuncio en Español al siguiente dirección: https://es.owner.ford.com/recall.

Si necesita ayuda o tiene alguna pregunta, por favor llame al Centro de Relación con Clientes al 1-866-436-7332 y presione 2 para Español.

 

Thank you for your attention to this important matter.

Ford Customer Service Division

 

January 2017

 

* * * IMPORTANT SAFETY RECALL * * *
(PROGRAMA DE SEGURIDAD IMPORTANTE)

 

Compliance Recall Notice 16S46 / NHTSA Recall 16V925
Aviso de Revisión de Seguridad 16S46

 

Mr. John Sample
123 Main Street
Anywhere, USA 12345

 

Your Vehicle Identification Number (VIN):  12345678901234567

This notice is sent to you in accordance with the National Traffic and Motor Vehicle Safety Act.

The Lincoln Motor Company has decided that a defect which relates to motor vehicle safety exists in your vehicle, with the VIN shown above.

We apologize for this situation and want to assure you that, with your assistance, we will correct this condition.  Our commitment, together with your dealer, is to provide you with the highest level of service and support.

What is the issue? It is possible that your vehicle was built with improperly brazed turbocharger oil supply tubes that may leak engine oil on the turbocharger and surrounding components.  An oil leak in the presence of an ignition source may increase the risk of fire.
What will Lincoln and your dealer do? The Lincoln Motor Company has authorized your dealer to inspect the turbocharger oil supply tubes for leaks and replace if a leak is present free of charge (parts and labor).
How long will it take? The time needed for this repair is less than one-half day.  However, due to service scheduling requirements, your dealer may need your vehicle for a longer period of time.  In addition, your vehicle will require an inspection to determine if parts need to be ordered.
What should you do? Please call your dealer without delay and request a service date for Recall 16S46.  Provide the dealer with your VIN, which is printed near your name at the beginning of this letter.

If you do not already have a servicing dealer, you can access www.Lincolnowner.com for dealer addresses, maps, and driving instructions.      

 The Lincoln Motor Company wants you to have this safety recall completed on your vehicle.  The vehicle owner is responsible for making arrangements to have the work completed.  The Lincoln Motor Company can deny coverage for any vehicle damage that may result from the failure to have this recall performed on a timely basis.  Therefore, please have this recall performed as soon as possible.

Please note:  Federal law requires that any vehicle lessor receiving this recall notice must forward a copy of this notice to the lessee within ten days.

(If) (SYNC VHR) Your vehicle may be equipped with a diagnostic feature called the Vehicle Health Report which can inform you about all available recalls, as well as other key vehicle health information. Please see https://owner.lincoln.com/vehiclehealth for more information.

What if you no longer own this vehicle? If you no longer own this vehicle, and have an address for the current owner, please forward this letter to the new owner.

You received this notice because government regulations require that notification be sent to the last known owner of record.  Our records are based primarily on state registration and title data, which indicate that you are the current owner.

Can we assist you further? If you have difficulties getting your vehicle repaired promptly and without charge, please contact your dealership’s Service Manager for assistance.

RETAIL OWNERS:  If you have questions or concerns, please contact our Customer Relationship Center at 1-866-436-7332 and one of our representatives will be happy to assist you.  If you wish to contact us through the Internet, our address is:  www.Lincolnowner.com.

For the hearing impaired call 1-800-232-5952 (TDD).  Representatives are available Monday through Friday:  8:00AM – 8:00PM(Eastern Time).

FLEET OWNERS:  If you have questions or concerns, please contact our

Fleet Customer Information Center at 1-800-34-FLEET, choose Option #3, and one of our representatives will be happy to assist you.  If you wish to contact us through the Internet, our address is:  www.fleet.ford.com.

Representatives are available Monday through Friday:  8:00AM – 8:00PM (Eastern Time).

If you are still having difficulty getting your vehicle repaired in a reasonable time or without charge, you may write the Administrator, National Highway Traffic Safety Administration, 1200 New Jersey Ave. S.E., Washington, D.C. 20590 or call the toll free Vehicle Safety Hotline at 1-888-327-4236 (TTY: 1-800-424-9153) or go to www.safercar.gov.  Reference NHTSA Safety Recall 16V925.

Para asistencia en Español Visite nuestro sitio web para ver este anuncio en Español al siguiente dirección: https://es.owner.lincoln.com/recall.

Si necesita ayuda o tiene alguna pregunta, por favor llame al Centro de Relación con Clientes al 1-866-436-7332 y presione 2 para Español.

 

Thank you for your attention to this important matter.

The Lincoln Motor Company

 

https://static.nhtsa.gov/odi/rcl/2016/RCMN-16V925-6292.pdf

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [265.18 KB]

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [305.21 KB]

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [80.93 KB]

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [82.45 KB]

 

https://static.nhtsa.gov/odi/rcl/2016/RMISC-16V925-3690.pdf

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [40.95 KB]

 

 

Leave a Comment

Share to...