| General Service Bulletin (GSB): | 12V Battery Charging and Testing Quick Reference Guide |
| GSB Overview: | Information on 12V battery types, proper charging & testing procedures along with proper 12V battery maintenance and storage |
| NOTE: This information is not intended to replace or supersede any warranty, parts and service policy, Work Shop Manual (WSM) procedures or technical training or wiring diagram information. | |
This GSB includes information on the following topics:
- Battery Performance Measurements
- Battery Types
- Battery Charging and Testing Procedures
- Battery Management System (BMS) Operation
- Battery Handling and Long Term Storage
Battery Performance Measurements
- State of Charge (SOC) – percentage (%)
- The amount of electrical energy stored in a battery at a given time expressed as a percentage of the energy when fully charged and dependent on the rate of discharge.
- Open Circuit Voltage (OCV) – volts (v)
- The voltage of a battery when it is not delivering or receiving power.
- Cold Cranking Amps (CCA) – amperes (a)
- The CCA rating is the number of amps that can be removed from a new fully charged battery at 0 deg F for 30 seconds while maintaining a voltage of at least 7.2v.
- Reserve Capacity (RC) – minutes (min)
Bestseller No. 1
NOCO GENIUS1: 1A 6V/12V Smart Battery Charger – Automatic Maintainer, Trickle Charger & Desulfator with Overcharge Protection & Temperature Compensation – for Lead-Acid & Lithium Batteries
- MEET THE GENIUS1 — Similar to our G750, just better. It's 35% smaller and delivers over 35% more power. It's the all-in-one charging solution - battery charger, battery maintainer, trickle charger, plus desulfator.
- DO MORE WITH GENIUS — Designed for 6-volt and 12-volt lead-acid (AGM, Gel, SLA, VRLA) and lithium-ion (LiFePO4) batteries, including flooded, maintenance-free, deep-cycle, marine and powersport batteries.
- ENJOY PRECISION CHARGING — An integrated thermal sensor dynamically adjusts the charge based on ambient temperature, preventing overcharging in hot weather and undercharging in cold, ensuring optimal battery performance.
- CHARGE DEAD BATTERIES — Charge batteries from as low as 1 volt, or use Force Mode to manually charge completely dead batteries down to zero volts. Perfect for recovering deeply discharged or neglected batteries.
- BEYOND MAINTENANCE — Keep your battery fully charged without worrying about overcharging. Our smart charger constantly monitors the battery, allowing you to leave it connected safely - indefinitely - for worry-free maintenance.
SaleBestseller No. 2
YONHAN Battery Charger 10-Amp 12V and 24V Fully-Automatic Smart Car Battery Charger, Battery Maintainer Trickle Charger, and Battery Desulfator with Temperature Compensation
- [All in One, Keep your battery charged and your car ready to go] This compact yet powerful 10-Amp 12V/24V smart battery charger is a versatile all-in-one solution, functioning as a charger, maintainer, trickle charger, and desulfator. It works with all 12V and 24V lead-acid batteries, including AGM, GEL, SLA, and Flooded types, for vehicles like cars, trucks, SUVs, motorcycles, lawnmowers, and boats. Note: For 12V/24V automotive or motorcycle batteries only. Not suitable for RC LiPo batteries or laboratory use.
- [Your Ultimate Winter Car Battery Companion] This smart car battery trickle charger has winter and summer modes to adjust charging based on temperature, preventing battery drain. It includes safety features like reverse polarity protection, overcharge protection, and short circuit prevention, ensuring safe and reliable charging. Perfect for keeping your car battery charged during cold winters or long breaks.
- [Enjoy Precision Charging, Your car deserves the best] This automotive battery charger has a backlit LCD that shows voltage, current, power percentage, temperature, and mode settings, making it easy to check your battery's health. It includes a thermal sensor to adjust charging, preventing overcharging in heat and undercharging in cold. The charger remembers your last mode and defaults to it after a power outage.
- [Restore your Battery, Don't let a dead battery ruin your plans] This battery charger includes an advanced repair mode to revive old or idle batteries and extend their lifespan. Use repair mode if the battery won't charge normally. Its high and low-frequency pulse technology helps restore and activate batteries, but it won't work on completely dead, damaged, or lithium batteries. Input line length：90cm, Output line length：65cm
- Note: 1. Our product is a car battery charger that requires connection to a power outlet for operation. 2. Regarding the power plug not making contact, this could be due to dirty battery terminals, loose clamps, or size mismatch. Please clean the terminals and ensure a firm connection. 3. This car battery charger cannot charge batteries voltage below 0.3V or batteries that are already damaged. 4. Always check your battery's voltage before attempting to charge. 5. If the battery indicator icon on the charger's display is flashing empty, this indicates that no battery has been detected, and charging will not be possible.
SaleBestseller No. 3
YONHAN Battery Charger 20A 12V/24V LiFePO4 Lead Acid Fully Automatic Battery Maintainer, Car Battery Trickle Charger Automotive w/Repair, Winter Mode, for AGM, STD, Gel, Deep Cycle Batteries
- [20A Suitable for LiFePO4 Lead-acid Battery Charger] 12V 20 Amp, 24V 10Amp 7-stage quick battery charger, Designed to charge, maintain and repair all 12-volt and 24-volt lead-acid automotive, LiFePO4, marine and deep-cycle batteries including AGM, GEL, EFB, SLA,Flooded(WET), Calcium in cars, truck, SUVs, ATV, motorcycle, snowmobile, lawn mower, boat, tractor, forklift, golf cart, etc. which is much faster than 10A or 6A automatic chargers. Note: This isn't a jump starter; it needs to be plugged into an outlet to work.
- [Winter Holiday Battery Trickle Charger]The car battery trickle charger features winter and summer modes with smart control to adapt to temperature changes and adjust the charging rate, preventing battery drain. It offers multiple protections, including reverse protection, a cooling system, overcurrent protection, fireproof materials, overcharge, and short circuit protection. These ensure safe charging, making it perfect for maintaining batteries over winter or during holidays.
- [High-efficiency Pulse Repair] Built-in advanced battery REPAIR mode to help recover old/idle batteries and extend battery life. If the battery cannot be charged, please use repair mode. The high-frequency and low-frequency pulse technology has good repair and activation effects, Automatically enters trickle/float charging mode after fully charged, keep maintaining your batteries during this winter and more, leave batteries for holiday months and still brand new when you back. pls Note: It can not repair a totally dead battery.
- [Brighter Screen Visualized Charging] Extra large LCD screen not only clear to see under the sunlight but also displays the charging and battery status; charge voltage and current, inside temperature, charge percentage, summer mode, winter mode, etc.
- Note: 1. Our product is a car battery charger that requires connection to a power outlet for operation 2. Before use, please carefully read the product manual and select the appropriate charging mode for your battery. 3. This car battery charger cannot charge batteries voltage below 0.3V or batteries that are already damaged. Not compatible with lithium batteries 4. Always check your battery's voltage before attempting to charge. 5. This battery charger is designed for temporary charging only and is not intended for permanent connection. Always disconnect the clamps from the battery after charging is complete.
Bestseller No. 4
NOCO GENIUS5: 5A 6V/12V Smart Battery Charger – Automatic Maintainer, Trickle Charger & Desulfator with Overcharge Protection & Temperature Compensation – for Lead-Acid & Lithium Batteries
- MEET THE GENIUS5 — Similar to our G3500, just better. It's 34% smaller and delivers over 65% more power. It's the all-in-one charging solution - battery charger, battery maintainer, trickle charger, plus desulfator.
- DO MORE WITH GENIUS — Designed for 6-volt and 12-volt lead-acid (AGM, Gel, SLA, VRLA) and lithium-ion (LiFePO4) batteries, including flooded, maintenance-free, deep-cycle, marine and powersport batteries.
- ENJOY PRECISION CHARGING — An integrated thermal sensor dynamically adjusts the charge based on ambient temperature, preventing overcharging in hot weather and undercharging in cold, ensuring optimal battery performance.
- CHARGE DEAD BATTERIES — Charge batteries from as low as 1 volt, or use Force Mode to manually charge completely dead batteries down to zero volts. Perfect for recovering deeply discharged or neglected batteries.
- BEYOND MAINTENANCE — Keep your battery fully charged without worrying about overcharging. Our smart charger constantly monitors the battery, allowing you to leave it connected safely - indefinitely - for worry-free maintenance.
Bestseller No. 5
FLHFULIHUA 12 Volt Battery Charger for Kids Ride on Toys - Universal Charger for Best Choice Products Wrangler SUV，Kid Trax Dynacraft ，Kidzone Bumper, ETL Listed
- FLHFULIHUA Class 2 Power Supply Model:LKC-120100-E/ Input: 100V -240VAC 50/60Hz.0.3A /OUTPUT:12VDC 1000MA / 6 Ft Power Cable / 2.1mm * 5.5mm Center Positive Barrel Plug.Fits 12 Volt Kids Ride On Toys.
- Compatibility:12v Ride On Battery Charger for Best Choice Products Wrangler SUV(only suitable for round hole charging port), Kid Trax Dynacraft ,Kidzone bumper car,flybar bumper car, Ferrari,Lamborghini,Mercedes,Tobbi Farm Tractor,12v scooters,such as Razor Power Core E90 E95, mx125
- Certified Safety: ETL Listed Efficient VI. Power use for rapid charging and Over Charge Protection, Over-current Protection, Short-circuit Protection.
- State two color LED indicates stage of charge. Red light Charging/ Green Light Fully Charged.
- Note:(Not Universal charger!) For 12V lead acid battery only 1.PLEASE check the Compatiblity and Connector Type before purchasing 2. Please make sure that the battery is in normal working condition and the plug is connected correctly when charging. 3. If the battery is stored for 1-2 months, it is recommended to check the battery status to ensure that the battery is not damaged. If you have any questions, please let us know, and we will do our best to answer them in a timely.
Last update on 2026-06-03 / Affiliate links / Images from Amazon Product Advertising API
This product presentation was made with AAWP plugin.